A SERVICE OF

logo

Open as PDF
next previous
Page20
7014-179D
December 16, 2011
R
CB 1200 Pellet Stove
D. Optional Brick Set Installation
1. Removethebaferst,followinstructionsonpage 34.
2. Slidebottomofleft rearbrickinrst;rotatetopedge
towardrearofapplianceandthen rotateouteredge
towardrearofappliance,until brickslidesintoplace.
Figure 20.1.
3. Repeatwithrightrearbrick.
4. Placeleftsidebrickalongleftsideofrebox,makingsure
chamfered(beveled)backedgeofbricktssnuglynext
torearbrick.Figure 20.2.
5. Repeatwithrightsidepanel.
6. Completebrickset,correctlyinstalled.Figure 20.3.
1
2
3
1
2
3
4
Figure 20.1
Figure 20.2
Figure 20.3
1. Afterthebricksethasbeeninstalled,2brickclipsneed
tobeinstalledontheouteredgeofeachbafetohold
thebricksetinplace.
2. Remove2bafesfromtheappliance.Slidethebafeup
andthebottomedgeshouldfalldownandthenliftthe
bafeout.
3. Usingpliers,bendthebrickclipslightlypast90°inthe
directionshowninFigure 20.4.
4. PositionthebrickclipasshowninFigure 20.4anduse
plierstocrimparoundtheoutsideedgeofthebafeas
showninFigure 20.5.
Note: Figure 20.5 shows the nished shape of the brick
clip, after being bent around the outside edge of
the bafe.
5. Slidethebafebackintoplacemakingsurethatthebrick
clipholdsthesidebricktowardthewalloftherebox.
Pushbackonthesidessotheywillkeeptherearbricks
inplace.Repeatforoppositeside.
Approximately
1 inch from corner
Top outside
corner of Baffle
Outside edge
of Baffle
Use pliers to crimp
Brick Clip around edge
Installed Clip
E. Brick Clip Installation
• Brickmayhavesmallwiresprotrudingfrom
thebackofbrick.
WARNING
RiskofInjury.
Figure 20.4
Figure 20.5
1