A SERVICE OF

logo

Open as PDF
next previous
R
December 16, 2011
7014-179D
Page25
CB 1200 Pellet Stove
G. Ignition Cycles
1. Duringeachignitioncycle,itisnormaltoseesome
smokeintherebox.Thesmokewillstoponcethe
restarts.
2. Theconvectionblowerwillautomaticallyturnonafter
yourappliancehasreachedthesettemperatureon
the“high”setting.Thisblowertransfersheatfromyour
applianceintotheroom,andwillcontinuetorunafter
thethermostathasstoppedcallingforheatuntilthe
appliancehascooleddown.
3. Occasionallytheappliancemayrunoutoffuelandshut
itselfdown.Whenthishappens,theredcalllightwill
beon.Torestartit,llthehopperandpressthereset
button.(See Figure 23.1, page 23).Whenyoupress
theresetbuttontheredcalllightwillgoout.Release
thebuttonandthelightwillcomebackon.Youshould
seeareshortly.Ifnot,followtheinstructionsonpage
24,of“StartingYourFirstFire”.
H. Frequently Asked Questions
Odorsandvaporsreleasedduringinitialoperation.
• Curingofhightemperaturepaint.
• Openwindowsforaircirculation.
Odorsmaybeirritatingtosensitiveindividuals.
CAUTION
WARNING
FireRisk
DoNOToperateappliance:
• Withappliancedooropen.
• Firepotooropen.
• Cleaningslideplatesopen.
DoNOTstorefuel:
• Closerthanrequiredclearancestocom-
bustiblestoappliance
• Withinspacerequiredforloadingorash
removal.
ISSUES SOLUTIONS
1. Metallicnoise. 1. Noiseiscausedbymetalexpandingandcontractingas
itheatsupandcoolsdown,similartothesoundpro-
ducedbyafurnaceorheatingduct.Thisnoisedoesnot
affecttheoperationorlongevityofyourinsert.
2. Ashbuilduponglass. 2. Thisisnormal.Cleantheglass.
3. Glasshasturneddirty. 3. Excessivebuildupofash.Thelowerburnsettingswill
producemoreash,thehigherburnsettingsproduce
less.Themoreitburnsonlowthemorefrequentclean-
ingoftheglassisrequired.
4. Firehastallameswithblacktailsandislazy. 4. Thefeedrateneedstobereducedortherepotneeds
cleaning.Heatexchangerofexhaustblowerneeds
cleaning.
5. Smokeystart-uporpuffsofsmokefromtheairwash. 5. Eithertherepotisdirtyorthereistoomuchfuelat
start-upandnotenoughair.Closedownfeedrate1/4
inchatatimeuntilthisnolongerhappens.
6. Largeameatstart-up. 6. Thisisnormal.Flamewillsettledownoncethereis
established.
Back side of Firepot
Firepot floor left open
Figure 24.1 - DO NOT LEAVE FIREPOT FLOOR OPEN